11
AG2 Series - 4” Tube Heater Installation, Operation, Maintenance and Parts Manual
AG2 Series Basic Parts List
AG2 SERIES PARTS LISTING
** 6' TOTAL NEEDED TO COVER OUTER EDGES OF A BURNER BOX.
PART # DESCRIPTION PART # DESCRIPTION
TP-1 CONTROL BOX COVER TP-200 BURNER (50 TO 100 MBTU/H)
TP-5 FLANGE GASKET TP-201B BURNER (125 MBTU/H TO 150 MBTU/H)
TP-9 CONDUIT COUPLING TP-202 16" BURNER TUBE W/ FLANGE
TP-10 CONDUIT 4" X 1/2" TP-204 GAS ORIFICE - CONSULT FACTORY
TP-11 GLO-BAR IGNITOR BOX TP-205 GLO-BAR HOLDER
TP-12 GLO-BAR IGNITOR BOX COVER TP-207 V.5/05 PRESSURE SWITCH MOUNTING BRACKET
TP-14 SIGHT GLASS GASKET TP-208 "Z" MOUNTING BRACKET
TP-15 SIGHT GLASS TP-211 MARK 17X-24 CIRCUIT BOARD
TP-16 SIGHT GLASS WASHER TP-211A MARK 17U-24 CIRCUIT BOARD (REMOTE SENSE)
TP-17 SIGHT GLASS KIT TP-212 1/2" X 3" PIPE NIPPLE
TP-19B WIRE HANGER TP-214 GLO-BAR WIRING HARNESS
TP-20C 120" REFLECTOR TP-217 PRESSURE BARB FITTING
TP-21B TUBE CLAMP TP-218 EXHAUST PRESSURE TUBE (VINYL)
TP-26A 10 FT. RADIANT TUBE STRAIGHT TP-221 GLO-BAR HOLDER GASKET
TP-26B 10 FT. RADIANT TUBE STRAIGHT (AL-TI) TP-222 FLAME ROD
TP-26C 10 FT. UNCOATED HOT ROLLED STEEL RADIANT TUBE TP-222A FLAME ROD WIRE
TP-31B CONTROL BOX HANGING BRACKET TP-223 GAS MANIFOLD
TP-33B 1/2" GAS COCK TP-303 END PANEL - RIGHT
TP-44 AIR ORIFICE W/SCREEN (CONSULT FACTORY) TP-825 HLRB RELAY BOARD
TP-50 GLO-BAR IGNITOR TP-826 40VA TRANSFORMER (OLD TP219)
TP-54 BURNER BOX DIVIDER TP-827 RED LED DISPLAY DIAGNOSTIC LIGHT
TP-55A FAN BLOWER TP-828 YELLOW OPERATIONAL IND. LIGHT (OLD TP216)
TP-65 33" INTERLOCKING HEAT DIFFUSER (BAFFLE) TP-840 36E96-224 TWO STAGE GAS VALVE-NAT (OLD TP210)
TP-68A STRAIN RELIEF BUSHING TP-841 36E96-226 TWO STAGE GAS VALVE-LP (OLD TP210P)
TP-70 CONTROL BOX COVER GASKET (PER FOOT**) TP-933 6' BLACK 120V THREE PRONG PLUG
TP-76 RUBBER GROMMET TP-934 6' YELLOW 24V CONTROL WIRE
TP-82 REFLECTOR CENTER SUPPORT TP-1402 END PANEL - LEFT
TP-83 STAINLESS STEEL FLEX CONNECTOR TP-1404 CONTROL BOX
TP-97 1/4" X 1/4" BRASS INT./EXT. ATMOS.BARB FITTING TP-NOPS NORMALLY OPEN DIFFERENTIAL SWITCH
TP-105 REFLECTOR END CAP (TP-264B) N.O. Differential Pressure Switch (65 TO 75MBTU/H)
TP-106 REFLECTOR CLIP (TP-264E) N.O. Differential Pressure Switch (100 TO 125MBTU/H)
TP-122 GASKET FOR AIR ORIFICE & AIR COLLAR (TP-264D) N.O. Differential Pressure Switch (150MBTU/H)
